Pipe Clamp Guide: Pipe Clips, Saddle Clamps, U-Bolts and Hose Clamps in Plastic, Steel and Stainless Steel, Sizes, Spacing, Vibration Pads, Outdoor Corrosion, Fitting and Indicative Rates in Pakistan
A pipe clamp holds a pipe to a wall, ceiling or frame, and the right type, size and spacing stop pipes sagging, rattling and loosening at joints. Prices run from about PKR 5 for a small plastic clip to PKR 400 for a heavy stainless clamp. This page covers pipe clips, saddle clamps, U-bolts and hose clamps in plastic, steel and stainless steel, sizes, spacing, vibration pads, outdoor corrosion, fitting and indicative rates in Pakistan. For related pages see PPRC pipes, flexible pipes and GI pipes.
Types of clamp
- Plastic pipe clip. A snap-in clip for PPR and PVC pipes.
- Saddle clamp. A metal strap with two screws, for heavier pipes.
- U-bolt. For pipes on rails and frames.
- Hose clamp. A band that tightens a hose onto a fitting.
Indicative rates
These ranges show common retail figures.
| Clamp | Indicative range |
|---|---|
| Plastic pipe clip, 20 to 32 mm | PKR 5 - 30 |
| Steel saddle clamp, 1 inch | PKR 20 - 80 |
| Rubber-lined clamp, 2 inch | PKR 60 - 220 |
| Stainless hose clamp | PKR 30 - 250 |
| U-bolt, each | PKR 30 - 300 |
| Anchors and screws, per set | PKR 10 - 60 |
Prices move with brand, model, size and stock. Use these ranges to judge a quote, then compare the exact model and what is included.
Sizes
Choose the clamp to match the pipe's outside diameter, not the nominal size. A loose clamp lets the pipe rattle and a tight one can crush plastic. Rubber lining helps hold and quiet metal clamps.
Spacing
Horizontal PPR and PVC pipe needs a clamp every 60 to 100 centimetres, closer for hot lines, which expand, and for larger pipes. Vertical pipes need support every 1.2 to 1.5 metres. Add a clamp near every joint, bend and valve.
Materials and corrosion
Plastic clips suit indoor plastic pipes. Galvanised steel suits indoor metal pipes, and stainless steel suits outdoors, damp areas and coastal air, where plain steel rusts quickly. Use stainless screws as well.
Vibration and noise
Pumps and fast-closing valves cause water hammer and vibration, so use rubber-lined clamps and flexible connectors and support pipes at the pump. Loose clamps make pipes knock.
What to check before buying
- Size. Fits the outside diameter
- Material. Plastic indoors, stainless outdoors
- Spacing. 60 to 100 cm horizontal
- Fixings. Right plugs and screws
Before you decide
Match the clamp to the pipe, space them properly and use stainless parts outdoors. Clamps are cheap and a missing one is the cause of many sagging, noisy pipes. Photograph the routes before plastering and give clips a final check when the system is first pressurised, and keep a few spare clips of each size so later repairs match the original work. Check every clip again after the first week of use, since plastic settles and a loose clip is easy to tighten before it becomes a rattle. Plumbing and gas work should be done by licensed tradespeople and pressure tested before it is covered.
Frequently Asked Questions
A fitting that holds a pipe to a wall, ceiling or frame. Ask for the specification in writing so you can compare quotes on the same basis. Check the warranty terms and who honours them before you pay. Measure carefully and confirm sizes with the seller before ordering.
As indicative ranges, a plastic clip is about PKR 5 to 30 and a rubber-lined steel clamp about PKR 60 to 220. Check the warranty terms and who honours them before you pay. Measure carefully and confirm sizes with the seller before ordering.
About 60 to 100 centimetres for horizontal plastic pipe. Measure carefully and confirm sizes with the seller before ordering. Rates and stock change, so confirm the current position before you commit. If you are unsure, send a photo and the measurements and we will advise.
Stainless steel. Rates and stock change, so confirm the current position before you commit. If you are unsure, send a photo and the measurements and we will advise. Ask for the specification in writing so you can compare quotes on the same basis.
Use rubber-lined clamps and flexible connectors near pumps. If you are unsure, send a photo and the measurements and we will advise. Ask for the specification in writing so you can compare quotes on the same basis. Check the warranty terms and who honours them before you pay.
Send the quantity, the size or rating and a photo of the space. We reply with a written rate that names the model and the warranty, and lists what is and is not included, so the comparison with other sellers is fair.
Choosing pipe clamps?
Send the details and a photo. We reply with a written rate.